Side of the road, no start...
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Side of the road, no start...
So I have put about 400 miles in about a week on my new to me 2004 vs1400. Bone stock, I turned 9,000 miles a couple of days ago.
Yesterday, after about 50 or 70 miles, i stopped at a park for a few minutes. Go to leave, bike won't start. Can't remember if the lights worked at that time, but wouldnt pushstart either. Disconnected the battery, reconnected and got it to start. Rode home without issue.
Rode it another 50 miles with no issue. Checked battery connections and applied a little dielectric grease.
Next day, ride 53 miles to work (mostly interstate) and stop for fuel two or three miles out. Go to start, turn key lights go on. Pull clutch and push starter, brief electrical noise, all lights out no power. Battery connections appear good, fuses under left cover good. Tow could start it with a jump box, but wouldn't stay running unless hooked up. All lights dim when running on the booster box.
New fully charged battery installed while at work. Bike starts and runs fine now. Old battery was "adventure power" brand. Tested at 7-8 volts by battery world.
Just a shot battery, or do you guys I probably have bigger issues? Hopefully it gets me all 53 miles home tonight....
I certainly won't shut her off til I get there.
Yesterday, after about 50 or 70 miles, i stopped at a park for a few minutes. Go to leave, bike won't start. Can't remember if the lights worked at that time, but wouldnt pushstart either. Disconnected the battery, reconnected and got it to start. Rode home without issue.
Rode it another 50 miles with no issue. Checked battery connections and applied a little dielectric grease.
Next day, ride 53 miles to work (mostly interstate) and stop for fuel two or three miles out. Go to start, turn key lights go on. Pull clutch and push starter, brief electrical noise, all lights out no power. Battery connections appear good, fuses under left cover good. Tow could start it with a jump box, but wouldn't stay running unless hooked up. All lights dim when running on the booster box.
New fully charged battery installed while at work. Bike starts and runs fine now. Old battery was "adventure power" brand. Tested at 7-8 volts by battery world.
Just a shot battery, or do you guys I probably have bigger issues? Hopefully it gets me all 53 miles home tonight....
I certainly won't shut her off til I get there.
- Blaine
- Passed the Circle Test
- Posts: 349
- Joined: Mon Jan 11, 2016 1:03 pm
- My Bike: 05 S83 07 M50
Re: Side of the road, no start...
Hopefully just battery....But wouldn't hurt to test charging output for peace of mind.....13 volts ideling ......14.4 or so when revved.
-
- Joined a 1100cc Club
- Posts: 5495
- Joined: Thu Dec 29, 2016 12:33 pm
- My Bike: VS800
Re: Side of the road, no start...
Star washers on the connections makes for a tight connection.
-
- Riding on Learners Permit
- Posts: 155
- Joined: Sun May 08, 2016 5:59 am
- My Bike: 2005 s83
Re: Side of the road, no start...
Star washers make for a consistent connection. I tried lock-tight and had the same problem as you, changed to start washers and new connections and nuts that was in a kit from JP cycle and no more problems.
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Update - the bike got me home with no issues. Did notice that the blue indicator light for the high beam only works about 70% of the time (high beam itself works), Unsure if related. The blue indicator doesn't flicker, but is sometimes delayed by up to a minute.
Star washers seem like a good idea, thanks.
Blaine, sorry if this is a stupid question, but where should I hook up to to test charging output?
Star washers seem like a good idea, thanks.
Blaine, sorry if this is a stupid question, but where should I hook up to to test charging output?
- Blaine
- Passed the Circle Test
- Posts: 349
- Joined: Mon Jan 11, 2016 1:03 pm
- My Bike: 05 S83 07 M50
Re: Side of the road, no start...
Right at the + & - on the battery with a voltmeter.
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Gotcha, thanks. Will be in work for the next few days, but will update. Will take the car until I know I have the bike sorted out...
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Update -
Tested the battery, 13.7 - 13.8v at a hot idle
12.5ish when revved above idle....
Maybe the trend continues and I'm discharging at road speed?
Any ideas?
Tested the battery, 13.7 - 13.8v at a hot idle
12.5ish when revved above idle....
Maybe the trend continues and I'm discharging at road speed?
Any ideas?
- Blaine
- Passed the Circle Test
- Posts: 349
- Joined: Mon Jan 11, 2016 1:03 pm
- My Bike: 05 S83 07 M50
Re: Side of the road, no start...
looking like your regulator/rectifer is going south.....12.5 above idle is discharging.cincykz wrote:Update -
Tested the battery, 13.7 - 13.8v at a hot idle
12.5ish when revved above idle....
Maybe the trend continues and I'm discharging at road speed?
Any ideas?
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
![Image](https://s22.postimg.org/nigtfglg1/20170607_071718.jpg)
Are green connectors under here factory? I'm actually having trouble even locating the reg/rec. Manual says remove seat and left cover but the picture is so grainy that I cant see what they have.
Appreciate the continued help, electrical has always been a little over my head...
-
- Passed the Circle Test
- Posts: 306
- Joined: Sun Feb 26, 2017 4:08 pm
- My Bike: Yamaha FZ-09 Suzuki S83
Re: Side of the road, no start...
It looks stock to me. This site might help you find the parts you're looking for.
http://www.cheapcycleparts.com/oemparts ... 0glp-parts
http://www.cheapcycleparts.com/oemparts ... electrical
See item #7. By the way, this part is under the bottom of the bike, just behind the engine and in front of the battery box.
http://www.cheapcycleparts.com/oemparts ... 0glp-parts
http://www.cheapcycleparts.com/oemparts ... electrical
See item #7. By the way, this part is under the bottom of the bike, just behind the engine and in front of the battery box.
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Thank you! I finally located the b/w/o/r/r from reg to harness, I will run the tests on the reg
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Contact cleaned and greased all of the underseat plugs and the right side plug to the regulator. About 13.5v at idle and 13.2 at revs. My multimeter doesnt have the 1kOhm setting that the book calls to use to test the regulator plug. Still trying to figure out how to run the regulator tests. Will update
- Blaine
- Passed the Circle Test
- Posts: 349
- Joined: Mon Jan 11, 2016 1:03 pm
- My Bike: 05 S83 07 M50
Re: Side of the road, no start...
13,5 at idle is real good...13.2 at rev not so much......Looking more & more like regulator going bad.cincykz wrote:Contact cleaned and greased all of the underseat plugs and the right side plug to the regulator. About 13.5v at idle and 13.2 at revs. My multimeter doesnt have the 1kOhm setting that the book calls to use to test the regulator plug. Still trying to figure out how to run the regulator tests. Will update
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Still trying to teach myself electrical testing... I see the Suzuki book says that if you don't use the Suzuki(c) pocket tester multi-meter, your numbers will be way off because of the secret sauce that Suzuki manufactures into their tester. I assume that there's not much to that and a generic tester should render acceptably accurate results?
In the mean time, I realized that a Caltric (cheap Chinese I assume?) replacement regulator/rectifier for the VS1400 (and referencing the Suzuki PN 32800-12E01) was $20.49 on Amazon shipped free, so I went ahead and ordered it as I've already spent a couple dozen times that in aggravation and wasted riding time...
I'm glad I cleaned the connections though, they were all tight and dirty with corrosion, so at least the rest of the electrical system should be happy now that it is clean and riding in dielectric grease. Most of my connectors were seized shut. Didn't look too horribly corroded, but almost impossible to separate before, now pinch the tab and pull right apart.
Thanks again for all the insight so far, I am sure we will be back and charging appropriately soon!
In the mean time, I realized that a Caltric (cheap Chinese I assume?) replacement regulator/rectifier for the VS1400 (and referencing the Suzuki PN 32800-12E01) was $20.49 on Amazon shipped free, so I went ahead and ordered it as I've already spent a couple dozen times that in aggravation and wasted riding time...
I'm glad I cleaned the connections though, they were all tight and dirty with corrosion, so at least the rest of the electrical system should be happy now that it is clean and riding in dielectric grease. Most of my connectors were seized shut. Didn't look too horribly corroded, but almost impossible to separate before, now pinch the tab and pull right apart.
Thanks again for all the insight so far, I am sure we will be back and charging appropriately soon!
- Herb
- Joined a 1200cc Club
- Posts: 19277
- Joined: Sun Oct 26, 2014 9:28 pm
- My Bike: 1999 1400 intruder
Re: Side of the road, no start...
I had this kind of issue and it turned out that the ground on the regulator was bad. Tapped in and ran an additional ground to the battery ground point. system works good.
I can't seem to win the lottery. I think I have used up all of my good luck riding motorcycles.
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Herb, that's an interesting point, especially because my reg came and was the wrong one... waiting on the right part in the mail again. Where does the reg ground to, just the battery box, or is there a connection somewhere that i missed?
Thanks in advance
Thanks in advance
- Herb
- Joined a 1200cc Club
- Posts: 19277
- Joined: Sun Oct 26, 2014 9:28 pm
- My Bike: 1999 1400 intruder
Re: Side of the road, no start...
It has a ground to the common ground. It is the black with white teacher. I think mine had bad connections. Tapped in just outside the regulator and ran it to the battery ground connection. This fixed my low charge issue. Never bothered to trace out where my problem was.
I can't seem to win the lottery. I think I have used up all of my good luck riding motorcycles.
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Good info Herb, thank you
- cincykz
- Tricycles are Cool
- Posts: 20
- Joined: Thu May 25, 2017 6:18 am
- My Bike: 2004 VS1400
Re: Side of the road, no start...
Update
Ground wire tested good
Caltric regulator/rectifier arrived, 10 minutes later, I'm in business. 13.2v at idle, increases steadily to just over 14 at revs.
Part was $27 on ebay, appears same quality as oem, plugged right in. Cable is about two inches longer than factory.
Thanks all for the help!
Ground wire tested good
Caltric regulator/rectifier arrived, 10 minutes later, I'm in business. 13.2v at idle, increases steadily to just over 14 at revs.
Part was $27 on ebay, appears same quality as oem, plugged right in. Cable is about two inches longer than factory.
Thanks all for the help!